Hybrid Synergy Drive Article Index for
Hybrid 		Website Links For
Hybrid 		 

Information About

Hybrid Synergy Drive
  CATEGORIES ABOUT HYBRID SYNERGY DRIVE
   
alternative propulsion
   
automotive transmission technologies
   
engine technology
   
hybrid powertrain
   
automotive technology tradenames
   
APPAREL
BABY
BEAUTY
BOOKS
CAR TOYS
CELL PHONES
DVD'S
ELECTRONICS
GOURMET FOOD
GROCERIES
HEALTH & PERSONAL
HOME & GARDEN
JEWELRY
MUSIC
MUSIC INSTRUMENTS
OFFICE PRODUCTS
SOFTWARE
SPORTING GOODS
TOOLS & HARDWARE
TOYS
VIDEO GAMES
SHOPPING HOME
MORE SHOPPING...



Hybrid Synergy Drive, ('''HSD''') is a set of and the Gearshift Lever in an HSD car merely send electrical signals to a control Computer .

HSD is a refinement of the original Toyota Hybrid System ('''THS''') used in the 1997–2003 Toyota Prius. As such it is occasionally referred to as '''THS II'''. The name was changed in anticipation of its use in vehicles outside the Toyota brand ( Lexus ; the HSD-derived systems used in Lexus vehicles were termed '''Lexus Hybrid Drive '''since 2006). The Lexus Hybrid Drive system has since been touted for its increase in vehicle power as well as environmental and efficiency benefits.

When required to classify the transmission type of an HSD vehicle (such as in standard specification lists or for regulatory purposes), Toyota describes HSD-equipped vehicles as having E-CVT ('''Electronically-controlled Continuously Variable Transmission''').

General Motors and DaimlerChrysler 's Global Hybrid Cooperation is similar in that it combines the power from a single engine and two motors. In contrast, Honda 's Integrated Motor Assist uses a more traditional ICE and transmission where the flywheel is replaced with an electric motor.

Some early non-production batteries and have 35 miles of electric range. Both of these systems leave the existing HSD system mostly unchanged and could be similarly applied to other hybrid powertrain flavors by simply replacing the stock NiMH batteries with a higher capacity Battery Pack and of course a charger to refill them for about $0.03 per mile from standard household outlets. Another provider of a plug-in module for the Toyota Prius is Hymotion .


THEORY OF OPERATION


HSD replaces a normal geared Transmission with an electronic system. All car Powertrain s drive a Driveshaft that turns the Drive Wheels of the car. Because an Internal Combustion Engine delivers energy best only over a small range of Torque and Speed , the crankshaft of the engine is usually attached to a switchable gear train that matches the needed torque at the wheels to the torque that can be delivered by the engine.

HSD replaces the gear box, , except that the torque/speed conversion uses electricity rather than direct mechanical connection. An HSD car cannot operate without the computer, power electronics, and MG2, though in principle it could operate while missing the gasoline engine. In practice, HSD cars can be driven a mile or two without gasoline, as an emergency measure to reach a Gas Station .

One of the motor-generators (MG2 in Toyota manuals; sometimes called "MG-T" for "Torque") is mounted on the driveshaft, and thus couples torque into or out of the driveshaft: feeding electricity into MG2 adds torque at the wheels. The engine end of the driveshaft has a second Differential ; one leg of this differential is attached to the gasoline engine and the other leg is attached to a second motor generator (MG1 in Toyota manuals; sometimes "MG-S" for "Speed"). The differential relates the rotation speed of the wheels to the rotation speeds of the engine and MG1, with MG1 used to absorb the difference between wheel and engine speed. The differential is an Epicyclic Gearset (also called a "power split device"); that and the two motor-generators are all contained in a single housing that is bolted to the Engine . Special couplings and sensors monitor rotation speed of each shaft and the total torque on the driveshaft, for feedback to the control computer.

The drive works by shunting electrical power between the two motor generators and the battery pack to even out the load on the gasoline engine. Since a power boost is available for periods of acceleration, the gasoline engine can be sized to match only the average load on the car, rather than its peak load: this saves fuel because smaller engines are more power efficient. Furthermore, during normal operation the gasoline engine can be operated at its ideal speed and torque level for power, economy, or emissions, with the battery pack absorbing or supplying power as appropriate to balance the demand placed by the Driver .


PHASES OF OPERATION


The HSD operates in distinct phases depending on speed and demanded torque. Here are a few of them:
  • Engine start: To start the engine, MG1 is fed negative voltage, so that it acts as a starter motor. The engine is forced into forward motion. Because both motor generators are sized to drive the entire car, turning the engine does not stress the motors and the conventional Starter Motor sound is not heard: engine start is silent. Engine start can occur when the car is stopped or moving.

  • Low gear (equivalent): When accelerating at low speeds in normal operation, the engine turns much more rapidly than the wheels, but does not develop as much torque as is needed. MG1 is forced rapidly backwards, and the computer pulls electricity from MG1. The electricity is shunted to MG2, adding torque at the driveshaft, so that the drive train develops power at low speed and high torque.

  • High gear (equivalent): When cruising at high speed, the engine turns more slowly than the wheels, but develops more torque than is needed. The computer pulls electricity from MG2, reducing the torque available at the wheels. The electricity is shunted to MG1, which boosts the speed of the driveshaft. Because the engine supplies Mechanical Energy to the whole system, Conservation Of Energy is not violated: the power that is shunted from MG2 to MG1 is less than the total power developed by the engine, and so power is delivered to the wheels.

  • Reverse gear: There is no reverse gear as in a conventional gearbox: the computer feeds negative voltage to MG2, applying negative torque to the wheels. Early models did not supply enough torque for some situations: there have been reports of early Prius owners not being able to back the car up steep hills in San Francisco . The problem has been fixed in recent models. If the battery is low, the system can simultaneously run the engine and draw power from MG1, although this will reduce available reverse torque at the wheels.

  • Silent operation: At slow speeds and moderate torques the HSD can drive without running the gasoline engine at all: electricity is supplied only to MG2, allowing MG1 to rotate freely (and thus decoupling the engine from the wheels). This is popularly known as "Stealth Mode." Provided that there is enough battery power, the car can be driven in this silent mode for some miles even without gasoline.

  • Neutral gear: Most jurisdictions require automotive transmissions to have a neutral gear that decouples the engine and transmission. The HSD "neutral gear" is achieved by turning the engine off. Under this condition, the planetary gear is stationary (if the vehicle wheels are not turning); if the vehicle wheels are turning, the ring gear will rotate, causing the sun gear to rotate as well (the engine inertia will keep the carrier gear stationary unless the speed is large), while MG1 freewheels so no power is dissipated.

  • ''' while saving the power for future boost. The HSD system has a special transmission setting labelled 'B' (for Brake), that takes the place of a conventional Automatic Transmission 's 'L' setting for engine braking on hills. If the battery is full, the system switches to conventional Compression Braking , drawing power from MG2 and shunting it to MG1, speeding the engine with throttle closed and so slowing the vehicle. The regenerative brakes in an HSD system absorb a significant amount of the normal braking load, so the conventional Brakes on HSD vehicles are undersized compared to brakes on a conventional car of similar mass.

  • Electric boost: The battery pack provides a reservoir of energy that allows the computer to match the demand on the engine to a predetermined optimal load curve, rather than operating at the torque and speed demanded by the driver and road. The computer manages the energy level stored in the battery, so as to have capacity to absorb extra energy where needed or supply extra energy to boost engine power.

  • Battery charging: The HSD can charge its battery without moving the car, by running the engine and extracting electrical power from MG1. The power gets shunted into the battery, and no torque is supplied to the wheels.



PERFORMANCE

The engine itself was also designed specifically to minimize engine drag with an offset Crankshaft to minimize piston drag during the Power Stroke , and a unique intake system to prevent drag caused by Manifold Vacuum versus the normal Otto Cycle in most engines.

The Highlander Hybrid (also sold as the Kluger in some countries) offers better performance compared to its non-hybrid version. The hybrid version goes from 0–60 mph in 7.2 seconds, trimming almost a second off the conventional version's time. Net hp is 268 hp compared to the conventional 215 hp. Top speed for all Highlanders are limited to 112 mph. Typical fuel economy for the Highlander Hybrid rates between 27 and 31 mpg. A conventional Highlander is rated by the EPA with 19 city, 25 highway mpg.

, the Ford Escape , though a hybrid Ford Fusion will be released with Ford's second-generation hybrid drivetrain in the future.http://media.ford.com/article_display.cfm?article_id=21988&make_id=trust The four-cylinder hybrid Escape achieves an increase in mileage, and is rated by the EPA with a combined 34 mpg, a 36% improvement over other similar sized SUVs from Subaru and Honda (Forester and CR-V, 25 mpg combined).http://www.fueleconomy.gov/feg/byclass/Sport_Utility_Vehicle2007.shtml

There have been reports in the press of hybrid power trains not living up to the EPA fuel efficiency claims. Fundamentally this is due to the artificial and unrealistic EPA testing procedure that manufacturers have learned to "game". The EPA testing procedure fails to recognize the sensitivity of hybrid mileage to driving style. The mileage boost depends on using the gasoline engine as efficiently as possible, which requires:
  • extended drives, especially in winter: Heating the internal cabin for the passengers runs counter to the design of the HSD. The HSD is designed to generate as little waste heat as possible. In a conventional car, this waste heat in winter is usually used to heat the internal cabin. In the Prius, running the heater will then require the engine to continue running to generate cabin-usable heat. This effect is most pronounced by turning the climate control (heater) off when at a stop when the engine is running. Normally the HSD control system will shut the engine off as it is not needed, and will not start it again until the generator reaches a maximum speed.

  • moderate acceleration: Because hybrid cars can throttle back or completely shut off the engine during moderate, but not rapid, acceleration, they are more sensitive than conventional cars to driving style. Hard acceleration forces the engine into a high-power state while moderate acceleration keeps the engine in a lower power, high efficiency state (augmented by battery boost).

  • gradual braking: Regenerative brakes re-use the energy of braking, but cannot absorb energy as fast as conventional brakes. Gradual braking recovers energy for re-use, boosting mileage; hard braking wastes the energy as heat, just as for a conventional car


Most HSD systems have batteries that are sized for maximal boost during a single acceleration from zero to the top speed of the vehicle; if there is more demand, the battery can be completely exhausted, so that this extra torque boost is not available. Then the system reverts to just the power available from the engine. This is a big difference in performance: an early-model Prius can achieve over 90 mph on a 6 degree upward slope, but after about 2,000 feet of altitude climb the battery is exhausted and the car can only achieve 55–60 mph on the same slope (until the battery is recharged by driving under less demanding circumstances).


DEVELOPMENT


The basic design of the Toyota Hybrid System / Hybrid Synergy Drive has not changed since its introduction in the 1997 Japanese-market Toyota Prius, but there have been a number of refinements.

The original Prius used shrink-wrapped 1.2 volt D cells; all subsequent THS/HSD vehicles have used custom 7.2 V battery modules mounted in a carrier. There has been a continuous, gradual improvement in specific capacity.

The Toyota Hybrid System relied on the voltage of the battery pack — between 276 and 288 V. The Hybrid Synergy Drive adds a DC To DC Converter boosting the potential of the battery to 500 V or more. This allows smaller battery packs to be used, and more powerful motors.

Although not part of the HSD as such, all HSD vehicles from the 2004 Prius onwards have been fitted with an electric air-conditioning compressor, instead of the conventional engine-driven type. This removes the need to continuously run the engine when cabin cooling is required. Although as noted above, the heat source for the Climate Control heater is still the gasoline engine and will run as long as heat is needed for the cabin.

Vehicles such as the Lexus RX 400h and Toyota Highlander Hybrid added four-wheel drive operation by the addition of a third electric motor ("MGR") on the rear axle. In this system, the rear axle is purely electrically powered, and there is no mechanical link between the engine and the rear wheels. This also permits regenerative braking on the rear wheels. In addition, the Motor (MG2) is linked to the front wheel transaxle by means of a second Planetary Gearset , thereby making it possible to increase the power density of the motor.

Ford has developed a similar hybrid system, introduced in the Ford Escape Hybrid .

The latest addition to the family of Hybrid Synergy Drivetrains is used in the Lexus GS 450h / LS 600h. This system uses two clutches (or brakes) to switch the second motors gear ratio to the wheels between a ratio of 3.9 and 1.9, for low and high speed driving regimes respectively. This decreases the power flowing from MG1 to MG2 (or vice versa) during higher speeds. The electrical path is only about 70% efficient, thus decreasing the power flow there increases the overall performance of the transmission. The second planetary gearset is extended with a second carrier and sun gear to a ravigneaux-type gear with four shafts, two of which can be held still alternatively by a brake/clutch.


Third generation


The third generation hybrid system from Toyota is expected to debut in the 2009 Toyota Prius , due out in late 2008 or early 2009. Toyota CEO Katsuaki Watanabe said in a February 16 , 2007 interview that Toyota was "aiming at reducing, by half, both size and cost of the Third-generation Hybrid System ."1
However, plans to replace , 2007 . Retrieved on 2007 - 08-07 . Lithium-ion batteries have a higher energy capacity-to-weight ratio, but cost more, and operate at higher temperatures, raising safety concerns.http://www.dailytech.com/Toyota+Shuns+Lithiumion+Batteries+for+Next+Gen+Prius/article7678.htm





LIST OF VEHICLES WITH HSD


:¹''Lexus Hybrid Drive''


CONTROVERSY

As of autumn 2005, the Antonov Automotive Technology BV Plc company has sued Toyota , the Lexus brand mother company, over alleged patent infringement relating to key components in the RX 400h's drivetrain and the Toyota Prius hybrid compact car. The case has been pending in secret since April 2005, but settlement negotiations did not bring a mutually acceptable result. Antonov eventually took legal recourse in the German court system, where decisions are usually made relatively swiftly. The patent holder seeks to impose a levy on each vehicle sold, which could make the hybrid SUV less competitive. Toyota fought back by seeking to officially invalidate Antonov's relevant patents. The court motion in Winword document format can be read here .

On 1st September 2006 Antonov announced: The Board of Antonov plc announces that the Federal Patent Court in Munich has not upheld the validity of the German part of Antonov's patent (EP0414782) against Toyota. A few days earlier, a court in Düsseldorf had ruled that the Toyota Prius driveline breached the Antonov hybrid CVT patent. Equivalent patents are still in force in various countries worldwide. The position is therefore that of a Mexican standoff, with the Toyota Prius probably breaching the Antonov hybrid CVT patents outside Europe, Antonov PLC lacking the financial muscle to enforce their patents, and Toyota prepared to try to get the Antonov patents cancelled elsewhere if Antonov tries to enforce them.
Reference Toyota gets Antonov hybrid CVT patent cancelled in Europe.


SEE ALSO




REFERENCES



EXTERNAL LINKS